2017 CHEVROLET VOLT

Sun Aug 17 2025

View source

- views

Complaint Summary

I was driving my car from Houston to Dallas when I got the "reduced propulsion" message and a check engine light. When I first saw the reduced propulsion issue I thought it might be related to the BECM issue again since I had already experienced that problem before. In the last few minutes of my trip the AC started to get hot and when I checked the coolant temperature I noticed it was around 240 - 255 F. I hadn't noticed it since there was no warning light for high temperature which I am used to with other cars. I'm not sure of the full extent of the issues yet, but I know for certain that the EGR valve has failed completely at about 71,500 miles. This is with very few miles on the actual ICE. I typically only use the ICE for a few hundred miles of driving each year. Fortunately for me, even though the CEL came on for the reduced propulsion I was able to reach my destination. However, when I went to leave, the car left me stranded as the ICE would shut down after a few minutes of running. The propulsion system is reduced and the engine becomes unavailable. Only the battery power will allow the car to drive. The F3 fuse in the EGR circuit blows if the engine is activated, and has happened multiple times already confirming the EGR issue. I have additional check engine lights that are a result of the EGR failure to circulate coolant properly. Below is a list of all the CEL codes that were pulled: P06DB P0030 P0031 P0403 P0405 P0443 P0458 P0489 P0597 P0598 P06DA P0AC4 P0135 P0AC4 P16E0 Looking into this issue I found that this is an one of the most common failures in the Chevy Volts but is no longer covered under the vehicle warranty and no bulletins posted for an extended warranty other than the BECM failure. This failure is so prevalent that I am surprised it is not.

Associated Stats:

Number of Reported Deaths	Number of Reported Injuries	Was There a Fire?	Was Medical Attention Required?
0	0	No	No

0 views